Fence - Gate Installation - Crossville TN

2026-11-03

Security Fence Approved Model – Ameristar Impasse II – Gauntlet Style or written approved equal , must provide spec sheets at time of bid if another manufacturer is used . - Install approximately 445 LF of 7 ’ tall security fence - Three - rail design - 2 . 75 ” wide Pales - 11 ga rails - 12 ga I beam posts , - Line post to be on 8 ’ centers , all posts set in concrete , minimum embed 36 ” - Black “ Perma - Coat ” finish with 15 - year warranty . - All posts set in concrete . Security Gates – total 2 : 1 Black Security and 1 Chain Link Approved Model – Ameristar Passport IS – Gauntlet Style or approved equal , must provide spec sheet at time of bid if another manufacturer is used . - Install ( 1 ) 24 LF 7 ’ tall security gate with steel V - Track roll gate design , 4 ” gate posts - Gate to have ( 2 ) 6 . 625 ” schedule 40 weight bollard posts with yellow bollard sleeve covers for protection , a total of 4 bollard posts . - Three - rail design - Black “ Perma - Coat ” finish with 15 - year warranty - All posts set in concrete . Chain link Gate – Rear Entrance to the Facility - ( 1 ) Auto slide gate ( 24 ’) wide cantilever 7 ’ tall . - Gate to match Chain link fencing . Chain Link Fence - Install approximately 600 LF of 6 ’ tall with galvanized chain link fence - with ( 3 ) strands of barbed wire , 12 . 5 - gauge , 4 - point barbs , max 5 ” o . c . - 9 - gauge fabric with 2 ” chain link mesh - 3 " WT / LG40 corner , end and pull posts . - 2 " WT / LG40 weight line posts , - 1 - 5 / 8 " diameter , 40 - weight , top rail - 7 - gauge bottom tension wire . - Line post to be on 10 ’ centers , all posts set in concrete - Tie in new fencing to existing chain link fence post using all new mechanical ties and new barbed wire as needed . - Selvages : Top and Bottom selvage twisted . Access Controls - Shall be compatible with existing AIPHONE system and tie in . - ( 2 ) dual height gooseneck - stand with two access control pads with AI - IX - DV cameras - Minimum 18 ” diameter concrete pad , embedded 24 ” in the ground , for gooseneck stand - install a ( 120v or 240v ) single phase circuit , from the nearest service panel in the facility to the gate operator with 1 ” fiberglass / HDPE or PVC conduit with pull string - install 1 ” fiberglass / HDPE or PVC conduit for data communication from existing AIPHONE master station IX - MV system to the access control pad / camera and operator with pull string - fully integrate the existing system with new components ; test & verify proper operation of controls - ( 2 ) protective 6 ” steel pipe bollards ( at each dual height gooseneck ), concrete filled , painted safety yellow , embedded 3 ’ in the ground in minimum 12 ’ diameter hole with concrete . Shall extend 48 ” above grade and be plumb in all directions . - In the event maximum distance exceeds 300 ’ and a repeater is necessary , this must be included in the bid . An as - built drawing with the repeater location noted must be provided to the State of TN . - Conduits shall be bored under any concrete or asphalt surfaces .

Tennessee

2026-05-05